filename: tfs 170n.doc version 1.6 11.04.2006 vi telefilter filter specification tfs 170n 1/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.com vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein without notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation. measurement condition ambient temperature: 23 c input power level: 0 dbm terminating impedance: * input: 780 ? || -7,9 pf output: 760 ? || -7.9 pf characteristics remark: the reference level for the relative attenuation a rel of the tfs 170n is the a ttenuation at nominal frequency f n . the maximum attenuation in the pass band is defined as the insertion loss a e . the nominal frequency f n is fixed at 170,6 mhz without any tolerance or limit. the values of relative attenuation a rel are guaranteed for the whole operating temperature range. the frequency shift of the filter in the operating temperature range is i ncluded in the production tolerance scheme. d a t a typ. value limit insertion loss a e 6,6 db max. 8 db nominal frequency f n - 170,6 mhz passband pb - f n 90 khz amplitude ripple in pb p-p 0,4 db max. 1 db relative attenuation a rel f n 90 khz ... f n 200 khz -0,1 db min. -1 db** f n 0,2 mhz ... f n 0,4 mhz 2 db min. 1 db f n 0,4 mhz ... f n 0,6 mhz 23 db min. 13 db f n 0,6 mhz ... f n 0,8 mhz 35 db min. 27 db f n 0,8 mhz ... f n 1,6 mhz 45 db min. 40 db f n 1,6 mhz ... f n 3 mhz 48 db min. 43 db f n 3 mhz ... f n 5,8 mhz 55 db min. 47 db f n 5,8 mhz ... f n 35 mhz 60 db min. 50 db f n 35 mhz ... f n 75 mhz 65 db min. 45 db f n - 75 mhz ... f n - 170 mhz 70 db min. 40 db f n + 75 mhz ... 2 ghz 70 db min. 40 db time domain response*** 5 sec 17 db min. 10 db 10 sec 35 db min. 20 db 30 sec 80 db min. 76 db 35 sec 83 db min. 79 db 40 sec 84 db min. 80 db group delay variation in pb 0,25 s max. 1 s vswr in pb 1,5:1 max. 2:1 input power level - max. 20 dbm temperature coefficient of frequency tc f **** -0,05 ppm/k 2 - frequency inversion temperature t 0 35 c - operating temperature range - - 33 c .. + 85 c storage temperature range - - 40 c.. + 125 c iip3 ***** 36 dbm min. 30 dbm *) the terminating impedances depend on paras ites and q-values of matching element s and the board used, and are to be understo od as reference values only. should there be additional ques tions do not hesitate to ask for an applic ation note or contac t our design team. **) reference is max. loss in pb ***) attenuation values for delays between 5s and 35s shall be interpolated linearly. ****) ? f(hz) = tc f (ppm/k 2 ) x (t-t 0 )2 x f to (mhz) ***** ) f in1 = 170,5 mhz; f in2 = 170,55 mhz; p in = 0 dbm f measurement = 170,6 mhz generated: checked / approved:
filename: tfs 170n.doc version 1.6 11.04.2006 vi telefilter filter specification tfs 170n 2/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.com vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein without notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation. filter characteristic construction and pin connection (all dimensions in mm) 13,3 0,2 6,5 0,2 1,80,2 1,910,2 7,620,2 1,00,2 1,90,2 date code 1 5 6 10 50 ? test circuit c1 l1 l2 c2 10 5 1, 2, 3, 4, 6, 7, 8, 9 tfs 170n u15 1 input rf return 2 ground 3 ground 4 ground 5 output 6 output rf return 7 ground 8 ground 9 ground 10 input date code: year + week u 2006 v 2007 w 2008 ... 168.6 169 169.4 169.8 170.2 170.6 171 171.4 171.8 172.2 172.6 -100 -90 -80 -70 -60 -50 -40 -30 -20 -10 0 frequency in mhz magnitude in db 170.35 170.4 170.45 170.5 170.55 170.6 170.65 170.7 170.75 170.8 170.85 -10 -9 -8 -7 -6 -5 -4 -3 -2 -1 0 frequency in mhz magnitude in db 170.35 170.4 170.45 170.5 170.55 170.6 170.65 170.7 170.75 170.8 170.85 1.29 2.04 2.79 3.54 4.29 5.04 5.79 6.54 7.29 8.04 8.79 frequency in mhz delay in s
filename: tfs 170n.doc version 1.6 11.04.2006 vi telefilter filter specification tfs 170n 3/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.com vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein without notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation. stability characteristics, reliability after the following tests the filter shall meet the whole specification: 1. shock: 500g, 1 ms, half sine wave, 3 shocks each plane; din iec 68 t2 - 27 2. vibration: 10 hz to 500 hz, 0,35 mm or 5 g respecti vely, 1 octave per min, 10 cycles per plan, 3 plans; din iec 68 t2 - 6 3. change of temperature: -55 c to 125c / 30 min. each / 10 cycles din iec 68 part 2 ? 14 test n 4. resistance to solder heat (reflow): reflow possible: three times max.; for temperature conditions refer to the attac hed "air reflow temperature conditions" on page 4; this filter is rohs compliant (2002/95/eg, 2005/618/eg) packing tape & reel: iec 286 ? 3, with exception of value for n and minimum bending radius; tape type ii, embossed carrier tape with top cover tape on the upper side; max. pieces of filters per reel: 1700 reel of empty components at start: min. 300 mm reel of empty components at start including leader: min. 500 mm trailer: min. 300 mm g do w ct f e g d1 p2 p1 po bo ao pull off direction pin marker typ date code ko t a c n w 1 w 2 the minimum bending radius is 45 mm. tape (all dimensions in mm) w : 24,00 +0,30/-0,10 po : 4,00 0,1 do : 1,50 +0,1/-0 e : 1,75 0,10 f : 11,50 0,10 g(min) : 0,60 p2 : 2,00 0,1 p1 : 12,00 0,1 d1(min) : 1,50 a o : 7,10 0,10 bo : 13,90 0,10 ct : 21,5 0,1 reel (all dimensions in mm) a : 330 w1 : 24,4 +2/-0 w2(max) : 30,4 n(min) : 60 c : 13,0 +0,5/-0,2
filename: tfs 170n.doc version 1.6 11.04.2006 vi telefilter filter specification tfs 170n 4/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.com vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein without notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation. air reflow temperature conditions conditions exposure average ramp-up rate (30c to 217c) less than 3c/second > 100c between 300 and 600 seconds > 150c between 240 and 500 seconds > 217c between 30 and 150 seconds peak temperature max. 260c time within 5c of actual peak temperature between 10 and 30 seconds cool-down rate (peak to 50c) less than 6c/second time from 30c to peak temperature no greater than 300 seconds temperature / c time / s max. 260c 217c 10 ... 30 s 30 ... 150 s max. 300 s chip-mount air reflow profile
filename: tfs 170n.doc version 1.6 11.04.2006 vi telefilter filter specification tfs 170n 5/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.com vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein without notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation. history version reason of changes name date 1.0 generation of ?development specification? acco rding to customer requirements pfeiffer 13.07.2004 1.1 package tolerances modified steiner 16.08.2004 1.2 terminating impedance added (pre liminary value) pfeiffer 17.09.2004 typical value and filter characteristic added definition for insertion loss changed limits for relative attenuation corrected 1.3 terminating impedance fixed pfeiffer 18.10.2004 air reflow temperat ure conditions modified 1.4 limit for maximum input power level fixed to 20 dbm pfeiffer 04.11.2004 air reflow temperat ure conditions modified 1.5 operating temperature range extended pfeiffer 31.03.2006 1.6 typical values and more details added for ip3 pfeiffer 11.04.2006 vswr typo corrected
|
